CAS #:

Linear Formula:

NiCuFeMn

MDL Number:

MFCD02091727

EC No.:

N/A

ORDER

PRODUCT Product Code ORDER SAFETY DATA TECHNICAL DATA
Nickel Copper Iron Manganese Rod
NICU-FEMN-01-R
Pricing > SDS > Data Sheet >

Nickel Copper Iron Manganese Rod Properties (Theoretical)

Compound Formula NiCuFeMn
Molecular Weight 233.03
Appearance Silvery Rods
Melting Point 1240 °C
Boiling Point N/A
Density N/A
Solubility in H2O N/A
Exact Mass 231.737923
Monoisotopic Mass 231.737923

Nickel Copper Iron Manganese Rod Health & Safety Information

Signal Word Warning
Hazard Statements H351-H317
Hazard Codes Xn
Risk Codes 11-40-43
Safety Statements 22-36/37
RTECS Number N/A
Transport Information UN3089 4.1/PG III
WGK Germany N/A
GHS Pictograms

View and Print SDS

SAFETY DATA SHEET

Date Accessed: 03/19/2024
Date Revised:01/15/2022

SECTION 1. IDENTIFICATION

Product Name: Nickel Copper Iron Manganese Rod

Product Number: All applicable American Elements product codes, e.g. NICU-FEMN-01-R

CAS #: 11105-19-4

Relevant identified uses of the substance: Scientific research and development

Supplier details:
American Elements
10884 Weyburn Ave.
Los Angeles, CA 90024
Tel: +1 310-208-0551
Fax: +1 310-208-0351

Emergency telephone number:
Domestic, North America: +1 800-424-9300
International: +1 703-527-3887


SECTION 2. HAZARDS IDENTIFICATION

Hazard description :
Xn Harmful
F Highly flammable
Information pertaining to particular dangers for man and environment
R 11 Highly flammable.
R 40 Limited evidence of a carcinogenic effect.
R 43 May cause sensitization by skin contact.
Classification system
HMIS ratings (scale 0-4)
(Hazardous Materials Identification System)
HEALTH ~
FIRE ~
REACTIVITY ~
GHS label elements
Health (acute effects) 2
Flammability 3
Reactivity = 2

Health Hazard - GHS08Flame - GHS02Exclamation Mark - GHS07

2.7/2- Flammable solid.
3.6/2 - Suspected of causing cancer.
3.4/1 - May cause an allergic skin reaction.
Prevention:
Obtain special instructions before use.
Do not handle until all safety precautions have been read and understood.
Keep away from heat/sparks/open flames/hot surfaces. - No smoking.
Ground/bond container and receiving equipment.
Use explosion-proof electrical/ventilating/lighting/ equipment.
Avoid breathing dust/fume/gas/mist/vapors/spray.
Contaminated work clothing should not be allowed out of the workplace.
Wear protective gloves/protective clothing/eye protection/face protection.
Use personal protective equipment as required.
Response:
IF ON SKIN: Wash with plenty of soap and water.
IF exposed or concerned: Get medical advice/attention.
Specific treatment (see label).
If skin irritation or rash occurs: Get medical advice/attention.
Wash contaminated clothing before reuse.
In case of fire: Use for extinction: C02 , powder or water spray.
Storage:
Store locked up.
Disposal:
Dispose of contents/container in accordance with local/regional/national/international
regulations.


SECTION 3. COMPOSITION/INFORMATION ON INGREDIENTS

Chemical characterization :
Description : (CAS# 11105-19-4)
Nickel (CAS# 7440-02-0), >63%
Copper (CAS# 7440-50-8), 28-34%
Iron (CAS# 7439-89-6), <2.5%
Manganese (CAS# 7439-96-5), <2%
Formu~a: 11105- 19- 4
Mo~ecu~ar Weight: 233 . 03


SECTION 4. FIRST AID MEASURES

If inhaled:
Supply fresh air and to be sure call for a doctor.
Supply patient with fresh air. If not breathing, provide artificial respiration. Keep patient warm.
Seek immediate medical advice.
In case of skin contact:
Immediately wash with soap and water; rinse thoroughly.
Seek immediate medical advice.
In case of eye contact:
Rinse opened eye for several minutes under running water. Consult a physician.
If swallowed:
Seek immediate medical advice.


SECTION 5. FIREFIGHTING MEASURES

Suitable extinguishing agents Special powder for metal fires. Do not use water .
For safety reasons unsuitable extinguishing agents Water
Protective equipment:
Wear self-contained respirator.
Wear fully protective impervious suit.


SECTION 6. ACCIDENTAL RELEASE MEASURES

Person-related safety precautions:
Use personal protective equipment. Keep unprotected persons away.
Ensure adequate ventilation
Keep away from ignition sources
Measures for environmental protection:
Do not allow material to be released to the environment without official permits.
Measures for cleaning/collecting:
Dispose contaminated material as waste according to item 13.
Ensure adequate ventilation.
Keep away from ignition sources.
Additional information:
See Section 7 for information on safe handling
See Section 8 for information on personal protection equipment.
See Section 13 for disposal information.


SECTION 7. HANDLING AND STORAGE

Handling
Information for safe handling:
Keep container tightly sealed .
Store in cool, dry place in tightly closed containers .
Ensure good ventilation at the workplace .
Prevent formation of dust .
Information about protection against explosions and fires:
Keep ignition sources away .
Protect against electrostatic charges .
Fumes can combine with air to form an explosive mixture .
Storage
Requirements to be met by storerooms and receptacles: Store in a cool location .
Information about storage in one common storage facility:
Do not store together with acids .
Do not store together with alkalies (caustic solutions) .
Store away from oxidizing agents .
Further information about storage conditions:
Keep container tightly sealed.
Store in cool , dry conditions in well-sealed containers .


SECTION 8. EXPOSURE CONTROLS/PERSONAL PROTECTION

Additional information about design of technical systems:
Properly operating chemical fume hood designed for hazardous chemicals and having an average
face velocity of at least 100 feet per minute .
Components with limit values that require monitoring at the workplace:
Manganese, elemental
ACGIH TLV
Austria MAK
Belgium TWA
Denmark TWA
Finland TWA
& inorganic compounds (as Mn)
mg/m3
0.2
5
5
2.5
0.5
Hungary TWA
Germany MAK
Japan OEL
Korea TLV
Netherlands MAC-TGG
Norway TWA
Poland TWA
Russia
Sweden NGV
United Kingdom TWA
USA PEL
Copper
ACGIH TLV
Austria MAK
Belgium TWA
Denmark TWA
Finland TWA
France VME
Germany MAK
Hungary TWA
Korea TLV
Netherlands MAC-TGG
Norway TWA
Poland TWA
Russia
Sweden NGV
Switzerland MAK-W
United Kingdom TWA
USA PEL TWA
0.3 ; 0.6-STEL
0.55
0.3 (respirable dust)
0.2
1 ; 3 -MAC-K
2.5
0. 3 ; 5-MAC
0.2-STEL (fume)
1 ; 2.5-TGV (respirable dust)
2.5 ; 5-TGV (total dust)
5
5-Ceiling
mg/m3
1 (dust, mist)
0.2 (fume)
1
0.1 (fume)
0.2 (fume)
1 (dust)
0.1
0.2 (fume)
1 (dust)
0.1 (fume)
1 (dust)
1 ; 2-STEL (dust)
0.1 (fume)
1 (dust)
0.2 ; 0.4-STEL (dust)
1 (dust, mist)
0.2 (fume)
1 (dust)
0.05
0.1 (fume)
0.1 ; 0.3-STEL (fume)
1 ; 2-STEL (dust)
1-STEL (dust)
0.2 (resp. dust)
1 (total dust)
0.1 ; 0.2-KZG-W (fume)
1 ; 1-KZG-W
0.2 (fume)
1 ; 2-STEL (dust, mist)
1 ; 3-STEL
0.1 (fume)
1 (dust, mist)
Nickel and inorganic compounds, as Ni
mg/m3
ACGIH TLV 1.5 ; AS (metal)
Austria
Denmark TWA
Finland TWA
France VME
Germany
Hungary
Japan OEL
Korea TLV
0.2 ; A1 (insoluble compounds)
0. 1 ; A4 I soluble compounds)
Carcinogen
0.5
0.1 (skin) Carcinogen
1 ; C3-Carcinogen
Carcinogen
0.005-STEL ; Carcinogen (insoluble compounds)
1 ; 2B-Carcinogen
1.5
Netherlands MAC-TGG 1 ; Carcinogen
1 (insoluble compounds)
Poland TWA 0.25
Russia
Sweden NGV
Switzerland MAK-W
United Kingdom TWA
USA PEL
0.05-STEL
0.5 (dust)
0.5 ; Carcinogen
0.1
1
Additional information : No data
Personal protective equipment
Follow typical protective and hygienic practices for handling chemicals.
Keep away from foodstuffs , beverages and feed.
Remove all soiled and contaminated clothing immediately.
Wash hands before breaks and at the end of work.
Breathing equipment : Use suitable respirator when high concentrations are present .
Protection of hands: Impervious gloves
Eye protection : Safety glasses
Body protection: Protective work clothing.


SECTION 9. PHYSICAL AND CHEMICAL PROPERTIES

General Information
Form : Powder
Color : Grey
Odor: Odorless
Melting point/ Melting range : No data available
Boiling point/ Boiling range : No data available
Sublimation temperature I start : No data available
Flash point : N/A
Flammability (solid, gas) Highly flammable .
Ignition temperature : No data available
Decomposition temperature : No data available
Explosion limits :
Lower : No data available
Upper : No data available
Vapor pressure : No data available
Density : No data available
Solubility in I Miscibility with
Water : Insoluble


SECTION 10. STABILITY AND REACTIVITY

Thermal decomposition I conditions to be avoided:
Decomposition will not occur if used and stored according to specifications .
Materials to be avoided:
Acids
Bases
Oxidizing agents
Dangerous reactions
Reacts with strong alkali
Reacts with acids
Reacts with oxidizing agents
Dangerous products of decomposition:
Hydrogen
Metal oxide fume


SECTION 11. TOXICOLOGICAL INFORMATION

Acute toxicity:
Primary irritant effect:
on the skin: Irritant to skin and mucous membranes.
on the eye: Irritating effect.
Sensitization: Sensitization possible through skin contact .
Subacute to chronic toxicity:
Chronic exposure to manganese may cause impairment to the central nervous system . Symptoms
include sluggishness, sleepiness, muscle weakness, loss of facial muscle control, edema,
emotional disturbances, spastic gait and falling .
Copper compounds may be irritating to the skin, eyes and respiratory tract . They may cause
metal fume fever, hemolysis of the red blood cells and injury to the liver, lungs, kidneys
and pancreas. Ingestion may also cause vomiting, gastric pain, dizziness, anemia, cramps,
convulsions, shock, coma and death.
Iron compounds may cause vomiting, diarrhea, pink urine, black stool, and liver damage. May
cause damage to the kidneys. Irritating to the respiratory tract, they may cause pulmonary
fibrosis if dusts are inhaled.
Nickel and nickel compounds may cause a form of dermatitis known as nickel itch. They may
also cause intestinal disorders, convulsions and asphyxia. Airborne nickel contaminated
dusts are regarded as carcinogenic to the respiratory tract.
Additional toxicological information:
To the best of our knowledge the acute and chronic toxicity of this substance is not fully
known.
EPA-A : human carcinogen : sufficient evidence from epidemiologic studies to support a causal
association between exposure and cancer.
IARC-2B : Possibly carcinogenic to humans : limited evidence in humans in the absence of
sufficient evidence in experimental animals.
NTP-2 : Reasonably anticipated to be a carcinogen: limited evidence from studies in humans or
sufficient evidence from studies in experimental animals.
ACGIH AS : Not suspected as a human carcinogen: Not suspected as a human carcinogen on the
basis of properly conducted epidemiologic studies in humans. Studies have sufficiently long
follow-up, reliable exposure histories, sufficiently high dose, and adequate statistical
power to conclude that exposure to the agent does not convey a significant risk of cancer to
humans. Evidence suggesting a lack of carcinogenicity in experimental animals will be
considered if it is supported by other relevant data.


SECTION 12. ECOLOGICAL INFORMATION

General notes:
Do not allow undiluted product or large quantities of it to reach groundwater, water course
or sewage system.
Do not allow material to be released to the environment without official permits.


SECTION 13. DISPOSAL CONSIDERATIONS

Product:
Recommendation Consult official regulations to ensure proper disposal.
Uncleaned packagings :
Recommendation: Disposal must be made according to official regulations.


SECTION 14. TRANSPORT INFORMATION

DOT regulations:
Hazard class: 4 . 1
Identification number: UN3089
Packing group: III
Proper shipping name (technical name): METAL POWDER , FLAMMABLE, N .O. S .
Label 4 . 1
Land transport ADR/RID (cross-border)
ADR/RID class:
Danger code (Kemler):
UN-Number:
Packaging group:
Description of goods :
Maritime transport IMDG :
IMDG Class :
UN Number:
Label
Packaging group:
Proper shipping name :
Air transport ICAO-TI and IATA-DGR :
ICAO/IATA Class :
UN/ID Number:
Label
Packaging group:
Proper shipping name :
4 . 1 (F3) Flammable solids, self-reactive substances
and solid desensitised explosives
40
3089
III
3089 METAL POWDER, FLAMMABLE, N.O.S. (nickel copper
iron manganese)
4.1
3089
4.1
III
METAL POWDER, FLAMMABLE, N.O.S.
4.1
3089
4.1
III
METAL POWDER, FLAMMABLE, N.O.S.
UN "Model Regulation" : UN3089, METAL POWDER, FLAMMABLE, N.O.S., 4.1, III


SECTION 15. REGULATORY INFORMATION

Product related hazard informations :
Hazard symbols :
Xn Harmful
F Highly flammable
Risk phrases :
11 Highly flammable.
40 Limited evidence of a carcinogenic effect .
43 May cause sensitization by skin contact .
Safety phrases :
22 Do not breathe dust.
36/37 Wear suitable protective clothing and gloves.
National regulations
All components of this product are listed in the U.S. Environmental Protection Agency Toxic
Substances Control Act Chemical substance Inventory.
This product contains a chemical known to the state of California to cause cancer or
reproductive toxicity.
Information about limitation of use:
For use only by technically qualified individuals.
This product contains nickel and is subject to the reporting requirements of section 313 of
the Emergency Planning and Community Right to Know act of 1986 and 40CFR372.
This product contains copper and is subject to the reporting requirements of section 313 of
the Emergency Planning and Community Right to Know Act of 1986 and 40CFR372.
This product contains manganese and is subject to the reporting requirements of section 313
of the Emergency Planning and Community Right to Know Act of 1986 and 40CFR372.


SECTION 16. OTHER INFORMATION

Safety Data Sheet according to Regulation (EC) No. 1907/2006 (REACH). The above information is believed to be correct but does not purport to be all inclusive and shall be used only as a guide. The information in this document is based on the present state of our knowledge and is applicable to the product with regard to appropriate safety precautions. It does not represent any guarantee of the properties of the product. American Elements shall not be held liable for any damage resulting from handling or from contact with the above product. See reverse side of invoice or packing slip for additional terms and conditions of sale. COPYRIGHT 1997-2022 AMERICAN ELEMENTS. LICENSED GRANTED TO MAKE UNLIMITED PAPER COPIES FOR INTERNAL USE ONLY.

About Nickel Copper Iron Manganese Rod

Nickel Copper Iron Manganese Alloy Rods are available in various dimensions and most volumes. American Elements can produce most materials in high purity and ultra high purity (up to 99.99999%) forms and follows applicable ASTM testing standards; a range of grades are available including Mil Spec (military grade), ACS, Reagent and Technical Grade, Food, Agricultural and Pharmaceutical Grade, Optical Grade, USP and EP/BP (European Pharmacopoeia/British Pharmacopoeia). We can also produce materials to custom specifications by request, in addition to custom compositions for commercial and research applications and new proprietary technologies. Typical and custom packaging is available, as is additional research, technical and safety (MSDS) data.

Nickel Copper Iron Manganese Rod Synonyms

Alloy C71640

Chemical Identifiers

Linear Formula NiCuFeMn
MDL Number MFCD02091727
EC No. N/A
Beilstein/Reaxys No. N/A
Pubchem CID 57346721
IUPAC Name copper; iron; manganese; nickel
SMILES [Mn].[Fe].[Ni].[Cu]
InchI Identifier InChI=1S/Cu.Fe.Mn.Ni
InchI Key OANFWJQPUHQWDL-UHFFFAOYSA-N

Packaging Specifications

Typical bulk packaging includes palletized plastic 5 gallon/25 kg. pails, fiber and steel drums to 1 ton super sacks in full container (FCL) or truck load (T/L) quantities. Research and sample quantities and hygroscopic, oxidizing or other air sensitive materials may be packaged under argon or vacuum. Shipping documentation includes a Certificate of Analysis and Safety Data Sheet (SDS). Solutions are packaged in polypropylene, plastic or glass jars up to palletized 440 gallon liquid totes, and 36,000 lb. tanker trucks.

Related Elements

Copper

See more Copper products. Copper Bohr Model Copper (atomic symbol: Cu, atomic number: 29) is a Block D, Group 11, Period 4 element with an atomic weight of 63.546. The number of electrons in each of copper's shells is 2, 8, 18, 1 and its electron configuration is [Ar]3d10 4s1. The copper atom has a radius of 128 pm and a Van der Waals radius of 186 pm. Copper was first discovered by Early Man prior to 9000 BC. In its elemental form, copper has a reddish-orange metallic and lustrous appearance. Of all pure metals, only silver Elemental Copperhas a higher electrical conductivity. The origin of the word copper comes from the Latin word 'cuprium' which translates as "metal of Cyprus," as the Mediterranean island of Cyprus was known as an ancient source of mined copper..

Iron

See more Iron products. Iron (atomic symbol: Fe, atomic number: 26) is a Block D, Group 8, Period 4 element with an atomic weight of 55.845. The number of electrons in each of Iron's shells is 2, 8, 14, 2 and its electron configuration is [Ar] 3d6 4s2. Iron Bohr ModelThe iron atom has a radius of 126 pm and a Van der Waals radius of 194 pm. Iron was discovered by humans before 5000 BC. In its elemental form, iron has a lustrous grayish metallic appearance. Iron is the fourth most common element in the Earth's crust and the most common element by mass forming the earth as a whole. Iron is rarely found as a free element, since it tends to oxidize easily; it is usually found in minerals such as magnetite, hematite, goethite, limonite, or siderite.Elemental Iron Though pure iron is typically soft, the addition of carbon creates the alloy known as steel, which is significantly stronger.

Manganese

See more Manganese products. Manganese (atomic symbol: Mn, atomic number: 25) is a Block D, Group 7, Period 4 element with an atomic weight of 54.938045. Manganese Bohr ModelThe number of electrons in each of Manganese's shells is [2, 8, 13, 2] and its electron configuration is [Ar] 3d5 4s2. The manganese atom has a radius of 127 pm and a Van der Waals radius of 197 pm. Manganese was first discovered by Torbern Olof Bergman in 1770 and first isolated by Johann Gottlieb Gahn in 1774. In its elemental form, manganese has a silvery metallic appearance. Elemental ManganeseIt is a paramagnetic metal that oxidizes easily in addition to being very hard and brittle. Manganese is found as a free element in nature and also in the minerals pyrolusite, braunite, psilomelane, and rhodochrosite. The name Manganese originates from the Latin word mangnes, meaning "magnet."

Nickel

See more Nickel products. Nickel (atomic symbol: Ni, atomic number: 28) is a Block D, Group 4, Period 4 element with an atomic weight of 58.6934. Nickel Bohr ModelThe number of electrons in each of nickel's shells is [2, 8, 16, 2] and its electron configuration is [Ar]3d8 4s2. Nickel was first discovered by Alex Constedt in 1751. The nickel atom has a radius of 124 pm and a Van der Waals radius of 184 pm. In its elemental form, nickel has a lustrous metallic silver appearance. Nickel is a hard and ductile transition metal that is considered corrosion-resistant because of its slow rate of oxidation. Elemental NickelIt is one of four elements that are ferromagnetic and is used in the production of various type of magnets for commercial use. Nickel is sometimes found free in nature but is more commonly found in ores. The bulk of mined nickel comes from laterite and magmatic sulfide ores. The name originates from the German word kupfernickel, which means "false copper" from the illusory copper color of the ore.

TODAY'S TOP DISCOVERY!

March 19, 2024
Los Angeles, CA
Each business day American Elements' scientists & engineers post their choice for the most exciting materials science news of the day
Enhancing CO Oxidation: The Impact of a Nanoscale Metal Oxide Layer on Gold and Platinum Nanoparticle Catalysts

Enhancing CO Oxidation: The Impact of a Nanoscale Metal Oxide Layer on Gold and Platinum Nanoparticle Catalysts